Punctures and cuts are common on-the-job injuries. Punctures occur when objects such as splinters, nails, glass, and sharp tools such as scissors and knives pierce the skin and cause a small hole. Cuts occur when sharp objects, including knives, scissors, sharp metal edges, and glass slice through the skin superficially or into the deeper layers of fat, tendons, muscles, and even bone.

The best way to deal with cuts and punctures is to avoid getting them in the first place. Wear appropriate clothing on the job such as sturdy shoes or work boots, long sleeve shirts, and long pants. Consider sturdy coveralls to protect your skin from sharp and flying objects. Wear personal protective equipment (PPE) appropriate to your job tasks such as gloves, safety glasses, work boots, gauntlets, and chaps.

Follow safe work practices and know how to use your tools properly. Inspect, maintain, and replace your tools when necessary. Always use the correct tool for the job. Ensure that blades on cutting tools are sharpened; dull cutting surfaces can cause accidents. When working with sharp tools, always know where both of your hands are at all times. Practice good housekeeping with your sharp and cutting tools by sheathing and storing them properly. Place tools far back on workbenches and shelves, not against the edge where someone walking by might get stuck.

If you have to pick up broken glass or metal shards, use a broom and a dustpan or pieces of cardboard. Never pick up broken glass with your bare hands. Dispose of sharp objects properly in rigid sided containers that will not get punctured and spill. Label these containers with the word “sharp” to warn coworkers of the hazard. Never reach into a garbage can with your hands or try to “tamp” it down with your hands or booted feet in case someone has improperly disposed of a sharp object or even a syringe. To properly dispose of syringes, pick them up with tongs and place them into hard plastic medical waste containers.

If you receive a puncture or cut on the job, notify your supervisor immediately. If you can, gently wash the area with soap and water. To stop bleeding, apply gentle pressure to the wound with clean gauze, cotton, or other absorbent material. When bleeding has stopped, apply an antibacterial ointment and a clean dressing to the wound. If you cannot stop the bleeding, if the wound is very large, or if you are impaled with an object, seek medical attention. Watch your wounds for signs of infection including fever, severe pain, redness beyond the wound edge, swelling, warmth, or pus drainage. Get medical attention immediately if you suspect infection.

If your wound was caused by stepping on a nail or other sharp object in contact with the soil, you may be exposed to the bacteria that causes tetanus. Consider getting regular boosters for tetanus every five-to-ten years. If your wound was caused by a needlestick, seek medical testing and treatment due to a potential exposure to bloodborne pathogens. Consider a Hepatitis B vaccination if you are exposed to potential needlesticks.

Any way you cut it, puncture and cut wounds expose you to pain and potential infection, so avoid them through good work practices.

Safety training sign-in sheet

Questions, Comments or Suggestions?

Send us your comments using the form below. To receive a response, please provide your email.

The above evaluations and/or recommendations are for general guidance only and should not be relied upon for medical advice or legal compliance purposes. They are based solely on the information provided to us and relate only to those conditions specifically discussed. We do not make any warranty, expressed or implied, that your workplace is safe or healthful or that it complies with all laws, regulations or standards.

External Link iconIndicates you are leaving Safe At Work California